KEY
EXPECTED
TEMPERATURES*
REFILL
INTERVALS
FUEL CHART/COMPONENTS
CAPACITY
+40F
0F
Above
to
to
(APPROX)
32F
-10F -65F
DF-2
2 qt.
DF-1
DF-A
AF - After
Diesel Fuel
AN - Every 1,500 Miles
VV-F-800
or annually
Fuel Filter
For Arctic Operation Refer to FM 9-207
NOTES
1. FUEL FILTERS. Daily, after operation, open drain
4. OIL CAN POINTS. Every 1,500 miles, semi-
cocks and drain water, debris, etc. from each filter until
annually, or as required, lubricate tailgate hinges,
clear fuel is flowing into container. Dispose of waste
cargo door hinges, and driver's throttle control linkage
through Unit SOP.
pins and shafts, and seat control.
2. On M1015A1 carriers, Iift up and secure center seat
5. LUBRICATED AT TIME OF ASSEMBLY. Coat
support panel to access primary fuel filter drain cock.
ends of suspension torsion bar, idler wheel support
arm spindle and bearings, steering control linkage
WARNING
bearing surfaces and pins, and towing pintle shaft with
Dry cleaning solvent PD-680 is toxic and flam-
GAA or GIA as specified during assembly. Late model
mable. Death or injury may result. Always use in
towing pintles do not have grease fittings and do not
an open area with good airflow, away from sparks,
require lubrication. Pack new support arm and idler
heat, or flames. Wear protective goggles and
hub before assembly.
gloves. Do not breathe vapors. Avoid contact with
skin, eyes, and clothes. If you get dizzy while using
A copy of this lubrication order will remain with the
solvent, breathe fresh air and get medical help. If
equipment at all times; instructions contained herein
solvent gets on hands, wash them. If solvent gets
are mandatory.
in eyes, flush eyes with fresh water and get medi-
cal help immediately. Keep fire extinguisher
By Order of the Secretary of the Army:
nearby.
GORDON R. SULLIVAN
3. AIR BOX DRAIN/CRANCKCASE BREATHER
General, United States Army
COLLECTION CAN (M548A1/M1015A1). Weekly, re-
Chief of Staff
move wing nuts. Lower can slowly to remove. Empty
can, dispose of contents per Unit SOP, and reinstall
Official:
(TM 9-2350-247-10). Every 25 hours, 250 miles, or
monthly, empty can and remove element. Clean ele-
MILTON H. HAMILTON
ment and inside of can with dry cleaning solvent (PD-
Administrative Assistant to the
680, type Ill) and reinstall.
Secretary of the Army
07303
DISTRIBUTION: To be distributed in accordance
with DA Form 12-37-E, block 1403,
requirements for LO 235<0-247-12.
PIN: 011897-000
398-894 (22013)
1995
U.S. GOVERNMENT PRINTING OFFICE:
0-
Card 40 of 40
